• <nav id="qsymg"><nav id="qsymg"></nav></nav>
  • 歡迎進入濟南濟柴環能燃氣發電設備有限公司官網!

    常見問題解答

    80千瓦燃氣發電機出現抖動診斷與處理方法

    80千瓦燃氣發電機在工作中出現抖動,除去發電機械噴油不正時、各缸工作不正常和各部機件磨損松曠等因素外,主要是支承不當引起的。
    The vibration of 80 kW gas generator in operation is mainly caused by improper support, except for the factors such as improper fuel injection timing of power generation machinery, abnormal operation of each cylinder and loose wear of various parts.
    ⑴原因
    (1) reasons
    ①發電機懸置斷裂。
    ① Broken generator mount.
    ②發電機懸置固定螺栓松動。
    ② The fixing bolts of the generator mount are loose.
    ③發電機懸置緩沖墊塊失效或脫落。
    ③ The generator suspension cushion block fails or falls off.
    ④發電機懸置位置不當,使傳動部分不同軸心。
    ④ The improper mounting position of the generator makes the transmission part different from the axis.
    ⑵80千瓦燃氣發電機診斷與處理方法
    ⑵ diagnosis and treatment methods of 80 kW gas generator
    ①診斷發電機的抖動可結合聲響來判斷。對于原地起動的發電機,如果沒有明顯的異響而抖動,說明是支承不牢固引起的,應仔細檢查懸置是否斷裂,固定螺栓是否松動,緩沖墊塊是否損壞或脫落,并及時修理。
    ① Diagnosis of generator jitter can be judged in combination with sound. For the generator started in place, if there is no obvious abnormal sound and shaking, it indicates that the support is not firm. Carefully check whether the suspension is broken, whether the fixing bolts are loose, and whether the buffer cushion block is damaged or fallen off, and repair it in time.
    ②如果原地起動發電機并沒有抖動,而架起驅動橋掛擋運轉后產生抖動,則說明是傳動部分同軸度偏差過大,應檢查懸置是否移位。檢查的方法是:在架起驅動橋的同時,擰松發電機固定螺栓,起動發電機運轉,觀察發電機懸置有無擺動現象,若有擺動,則肯定是傳動部分同軸度偏差過大,應予調整。
    ② If the generator does not vibrate when it is started in place, but vibrates after the drive axle is put into gear, it indicates that the coaxiality deviation of the transmission part is too large. Check whether the suspension is displaced. The inspection method is: while erecting the drive axle, loosen the fixing bolts of the generator, start the generator for operation, and observe whether the generator suspension swings. If there is swing, it must be that the coaxiality deviation of the transmission part is too large and should be adjusted.
    ③如果發電機原地起動后有異響,且排氣煙色不正,則應按噴油不正時、各缸供油不均和個別缸不工作進行排除。
    ③ If there is abnormal noise after the generator is started in place and the exhaust smoke color is not correct, it shall be eliminated according to improper fuel injection timing, uneven fuel supply of each cylinder and non operation of individual cylinders.
    ④對于使用已久的或在惡劣環境下工作的發電機,若異響較明顯,應視各機件的松曠程度,予以檢修處理。
    ④ For generators that have been used for a long time or work in harsh environment, if the abnormal sound is obvious, they shall be overhauled according to the looseness of each machine part.
    ⑤對于剛維修不久的車輛,則應考慮是否屬動平衡失效而造成的車輛抖動。
    ⑤ For the vehicle that has just been repaired for a short time, consider whether it is the vehicle jitter caused by dynamic balance failure.
    新聞搜索
    濟南濟柴環能燃氣發電設備有限公司
    • 服務熱線

      0531-62325028
      0531-69951266

    80千瓦燃氣發電機出現抖動診斷與處理方法

    80千瓦燃氣發電機在工作中出現抖動,除去發電機械噴油不正時、各缸工作不正常和各部機件磨損松曠等因素外,主要是支承不當引起的。
    The vibration of 80 kW gas generator in operation is mainly caused by improper support, except for the factors such as improper fuel injection timing of power generation machinery, abnormal operation of each cylinder and loose wear of various parts.
    ⑴原因
    (1) reasons
    ①發電機懸置斷裂。
    ① Broken generator mount.
    ②發電機懸置固定螺栓松動。
    ② The fixing bolts of the generator mount are loose.
    ③發電機懸置緩沖墊塊失效或脫落。
    ③ The generator suspension cushion block fails or falls off.
    ④發電機懸置位置不當,使傳動部分不同軸心。
    ④ The improper mounting position of the generator makes the transmission part different from the axis.
    ⑵80千瓦燃氣發電機診斷與處理方法
    ⑵ diagnosis and treatment methods of 80 kW gas generator
    ①診斷發電機的抖動可結合聲響來判斷。對于原地起動的發電機,如果沒有明顯的異響而抖動,說明是支承不牢固引起的,應仔細檢查懸置是否斷裂,固定螺栓是否松動,緩沖墊塊是否損壞或脫落,并及時修理。
    ① Diagnosis of generator jitter can be judged in combination with sound. For the generator started in place, if there is no obvious abnormal sound and shaking, it indicates that the support is not firm. Carefully check whether the suspension is broken, whether the fixing bolts are loose, and whether the buffer cushion block is damaged or fallen off, and repair it in time.
    ②如果原地起動發電機并沒有抖動,而架起驅動橋掛擋運轉后產生抖動,則說明是傳動部分同軸度偏差過大,應檢查懸置是否移位。檢查的方法是:在架起驅動橋的同時,擰松發電機固定螺栓,起動發電機運轉,觀察發電機懸置有無擺動現象,若有擺動,則肯定是傳動部分同軸度偏差過大,應予調整。
    ② If the generator does not vibrate when it is started in place, but vibrates after the drive axle is put into gear, it indicates that the coaxiality deviation of the transmission part is too large. Check whether the suspension is displaced. The inspection method is: while erecting the drive axle, loosen the fixing bolts of the generator, start the generator for operation, and observe whether the generator suspension swings. If there is swing, it must be that the coaxiality deviation of the transmission part is too large and should be adjusted.
    ③如果發電機原地起動后有異響,且排氣煙色不正,則應按噴油不正時、各缸供油不均和個別缸不工作進行排除。
    ③ If there is abnormal noise after the generator is started in place and the exhaust smoke color is not correct, it shall be eliminated according to improper fuel injection timing, uneven fuel supply of each cylinder and non operation of individual cylinders.
    ④對于使用已久的或在惡劣環境下工作的發電機,若異響較明顯,應視各機件的松曠程度,予以檢修處理。
    ④ For generators that have been used for a long time or work in harsh environment, if the abnormal sound is obvious, they shall be overhauled according to the looseness of each machine part.
    ⑤對于剛維修不久的車輛,則應考慮是否屬動平衡失效而造成的車輛抖動。
    ⑤ For the vehicle that has just been repaired for a short time, consider whether it is the vehicle jitter caused by dynamic balance failure.
    久久伊人精品制服丝袜,日本Av一区二区三区2019免费,91在线视频+国产,台湾swag吴梦梦挑战视频在线,日韩成色午夜电影在线观看,国产美女自慰福利在线主播,少女萝莉先峰,k频道日韩国产网红 影音资源 国产直播| 麻豆传媒沈芯语花絮| 和麻豆传媒差不多的软件| 黑洞 韩国| 麻豆映画传媒妙龄相亲女| 欧美墙纸高清图片大全| 欧美眼睛画法| 麻豆传媒映画映安全吗| 麻豆传媒MD0096| 国产sm小三女虐女调教原配| 保定出差偷拍国产| 制服师生国产| 欧美人兽电影| 91福利免费体验在线观看| 中文字幕拍摄技巧| jux790中文字幕| 国产直播系列磁力链接| 韩国青训| 午夜两点半电影在线观看| hd国产剧情主播| 老司机国产情侣在线高清在线视频| 麻豆传媒最新出品在线观看| 欧美红色礼服| 日本邪恶工口动漫| 台湾女同性恋 切除乳房| 麻豆映画传媒官网免费| 偷拍国产下药| 视频一区国产专区FC2ppv| 日韩国产欧洲网红无码| 国产sm视频迅雷种子下载| 色情直播国产美女图片| 韩国厨师招聘| 台湾麻豆传媒最新地址| 韩国限级中文字幕电影| 鬼动漫全集中文字幕免费在线看| 罕见萌白酱一线天在线| 国产剧情d视频在线播放| 亚洲国产偷拍高清视频| 国产18禁直播 下载 迅雷下载| 韩国炸猪排| 国产直播与儿子磁力| http://www.ljptw.com http://www.computerrentalsoftware.com http://www.magicien-foxy.com http://www.duishou.net http://www.argent-cabu.com http://www.ydart.net